Westsail Owners Alliance - Post: "Cockpit & Scupper Drains"
Westsail Westsail Owners Affiliation
 Important information about this site! 

Post: "Cockpit & Scupper Drains"

12,268 posts on 2,444 threads   •   From Mar 07, 2004 - Jan 08, 2012

How

Text Strings  

Full Phrase  

Which

All Words  

Any Word  

Where

Message Text

Text & Author  

What
Message Author Message Content   (1 of 1)
- Archived Message from Inactive Forum -

Bud Taplin
(Member)

The cockpit drain seacocks were located where the hose took a smooth curve, and that was below the waterline because the cockpit floor was close to the waterline. The original cockpit floor slanted down forward. It should have slanted down aft, with the drains having a 90 degree elbow and the outlets above the water, and aft. I know of one owner that recut his cockpit floor to do this.

When Westsail made the depressions in the deck for the scupper drains, and had the 2" spun brass fitting, with it's flange, a small amount of water always sat in the depression. They then put a small thruhull and hose in the bottom of the depression to drain out most of this small amount of water, and connected it to a tee on the cockpit drain. This was probably not too good an idea (I was no longer working for Westsail when this was done, so don't blame me). I believe that eventually they put in another thruhull just above the waterline to drain this small hose. Unfortunately, these small hoses often clog.

My solution to the whole problem would be to install a fiberglass scupper drain, low enough in the depression to drain it all, and going out through the hullside.

I have also seen another solution; filling the low spot in the depression with fiberglas putty up to the level of the existing scupper drain.

Showing record #1 of 1 matching record


Showing record #1 of 1 matching record

  Forum Archive Home    Back to Previous Page   Show Posts w/ Images   Windbag Newsletter 
This site is provided as service to Westsail Owners by Jack Webb on Westsail 32, Hull #438, at http://HighSeasDrifter.net,
This site is provided as service to Westsail Owners by  Jack Webb (s/v Drifter, Westsail 32, Hull #438)